Trash Compactor Door Stuck Closed

There s a lot of air in your kitchen waste which a trash compactor essentially removes.

Trash compactor door stuck closed. There is nothing jammed in the back. If your trash compactor drawer will not open there may be an issue with one or more of the drawer rollers. This video demonstrates the proper and safe way to disassemble a trash compactor and how to access parts that may nee. These rollers can be warped or simply lack lubrication to slide the drawer open easily.

The bin drawer is stuck closed. A trash compactor can handle any garbage that you would normally put into a garbage can. The compactor is a kitchenaid kcs 100 and over 10 years old. A trash compactor is a handy appliance that can be located in your kitchen.

If your trash compactor is jammed or stuck with the ram in the down position the problem may be with the drive gear. It s to late this evening to call and see if it s still. If all else fails the problem is deeper than the door being temporarily stuck or improperly closed. In that case once you are able to open the door of the compactor try to spot any damage to these parts.

This switch is activated by a metal tab atop the ram and controls the direction of the ram. The door on trash compactor will not close. The drawer was not completely closed when the ram was activated. The drive motor has a small gear attached to the shaft and this gear meshes with the larger drive gear which in turn operates the chain that powers the ram screws.

To check the rear drawer rollers lift the drawer out of its opening and. On most trash compactors the drawer uses rollers to slide open and closed. That recently happened with my mil s and we attempted to mash the contents and nothing happened and the door was stuck in the closed position. If the foot pedal on your compactor does not release the drawer easily or the drawer won t stay closed it may be damaged.

Trash compactor door is stuck closed how to open. We have checked the circuit breaker and reset it. Repairing a kitchenaid trash compactor. The foot pedal on most trash compactors is used to disengage the drawer from the frame and it is secured to the drawer with shoulder screws so that it can pivot easily.

Directional switch failure due to the contacts becoming welded shut or stuck open can result in the ram getting stuck at the bottom of its cycle. A large metal plate that is powered by pneumatics crushes the garbage down into a small block.